doodah

truck will start fine one time , and will not start at all the next . any ideas ?

phox_mulder

Memory isn't what it used to be, diesel fumes probably aren't helping,<br>What year truck do you have?<br><br>phox

doodah

its a 97 and right now this morning as i speak i cant get it to start at all. it acts like it aint gettin fuel.

Rammin On

Check the fuel shutdown soleniod ...

berner

Check your shutdown solenoid to make sure it's opening. It opens when you engage the starter. If it's not opening you can lift up on the plunger rod with the key on and it should stay up until you shut the truck down.

doodah

where exactly is this located at? there is a like a bulb valve on the drivers side of the motor and this is soft isnt it supposed to be hard?

Rammin On

It's round and has a rod attached covered with a rubber boot .... it's bolted to your AFC ...... pull up on it and see if it starts .... relay could be bad or the soleniod shot ... or sticking .... <br><br>

doodah

afc?

Rammin On

Aneriod Fuel Control on the injection pump .... just aft of where all the fuel lines are ... looks like a hump on the back of the pump ...

Rammin On

Here's a pic

Rammin On

And another

doodah

sorry, i just cant seem to see what your refering to is it on the top side of pump towards the motor itself or what. is it something i need a pliers or screwdriver to lift or what? looked all over for this. still kindof new to this motor.

Rammin On

the solenoid is located on the injection pump towards the firewall on the drivers side. There is a plunger rod that is attached to the pump lever. Pull up on the lever.

berner

Here's a link to a diagram which shows where it is. Engine Diagram

doodah

i think it is mybe a cracked fuel line. if i crack open the #1 injector and turn it over, i can get it to start but i will have to get a buddy over so i can close the line after i get it started.. prognosis-- air in the fuel line??? ???